Pontiac Product Service Publication - Service Bulletins and Product Campaigns - PDFs

Status
Not open for further replies.
Jan Larsson

Jan Larsson

Administrator
Staff member
#1
#1
Below you will find a library of the Pontiac issued Dealer Service Bulletins and Product Campaigns.
(Some downloads have a link next to them others have the download as an attachment in the post; this is due to file size limitations on the forum but important thing is all downloads are in each section)

These were published and sent to the dealers and not for general avalability to the public; they contain everything from service manual updates, special repair procedures due to whatever issues they found after the cars where built and any safety campaigns / recalls made.

There were 1000's issued in total however below please find PDF versions of the ones related to our cars, some specific to the TTA others covering the Firebird (and the TTA) in general for certain years.

I've listed them in the order they are published in the summary books (photo of books below) to make it easy to find what you are looking for.

Note: this thread is NOT for technical support on the content and please only PM me if there's something wrong wiht the PDFs (page missing, pages in wrong order or similar) NOT with regards to technical questions of the content.

Component Category Description
0 General Information, Maintenance and Lubrication
1 Heating, Ventilation and Air Conditioning
2 Frame, Bumpers, Chassis and Sheet Metal
3 Steering, Suspension, Wheels and Tires
4 Propeller Shaft and Rear Axle
5 Brakes
6A Engine Mechanical
6B Engine Cooling
6C Fuel System
6D Engine Electrical
6E Engine Driveability and Emissions
6F Exhaust System
6H Engine Vacuum Pumps
6J Turbocharger
7A Automatic Transmission/Transaxle General Information
7E Automatic Transmission – 200, 200C, 200-4R
8 Chassis and Body Electrical
9 Accessories
10 Body
C Campaigns
 

Attachments

Last edited:
Jan Larsson

Jan Larsson

Administrator
Staff member
#2
#2
0 - General Information, Maintenance and Lubrication

89-0-4 Predelivery Information Turbo Intercooler Duct for the 20th Trans Am

90-0-2 Federal Vehicle Theft Prevention Standard (Anti-Theft Labeling)
 

Attachments

Last edited:
Jan Larsson

Jan Larsson

Administrator
Staff member
#8
#8
6 - Engine Mechanical, Engine Cooling, Fuel System, Engine Electrical, Engine Driveab

6 - Engine Mechanical, Engine Cooling, Fuel System, Engine Electrical, Engine Driveability and Emissions, Exhaust System, Engine Vacuum Pumps, Turbocharger

89-6-42 Water in Air Cleaner - (Procedures) - 20th Anniversary Trans Am

91-6-7 Fuel Filler Cap Cross Threading (Replace Cap)
 

Attachments

Last edited:
Jan Larsson

Jan Larsson

Administrator
Staff member
#9
#9
7A, 7E - Automatic Transmission/Transaxle General Information, 200-4R

7A Automatic Transmission/Transaxle General Information
7E Automatic Transmission – 200, 200C, 200-4R

Nothing yet
 
Jan Larsson

Jan Larsson

Administrator
Staff member
#12
#12
10 - Body

89-10-8A "Aero-Wing" Spoiler (D-81) New Part and Revised Paint Procedure

89-10-10A Procedure for Replacement of D-81 "Aero-Wing" Spoiler

89-10-17 New Acrylic T-top Panels and Latching System (Information)

89-10-34 Acrylic T-tops Panels (Replace With Glass Panels)

90-10-19 Tire to Plastic Wheelhouse Interference on Firebird Models with 16" Wheels

91-10-2 Firebird Roof Area Water Leaks (Procedure for Seal Weld Areas)

91-10-10 Information on T-top Weatherstrips and Attachements

91-10-11 Buzz or Rattle Near A-Pillar Area (Replace Push In Fasteners)

91-10-16 Squeaks from Rear of Doors (New Body Side Wedge Plate)

91-10-19A Rear Compartment Waterleaks (New Weatherstrip and Seal Kit)

91-10-25 T-top Sealing Strip - Awnings (New Replacement Parts)

91-10-37 New T-top Weatherstrips With Drain Provisions at Butt Joints (New Service Kit)
 

Attachments

Last edited:
Status
Not open for further replies.
Top Bottom